06
Jul
Lay okb the engine follow the par str hose to the starboard rear corner of the engine. I removed the steering ram to check it and with the flats on the actuator oriented horizontally the cylinder will move and push fluid but when hooked up and the engine running it wants to constantly turn the outdrive to the starboard side.
I replaced the steering sensors lift cylinders every hydraulic line the steering computer a power steering control valve power steering pump.
Volvo penta power steering problems. About Press Copyright Contact us Creators Advertise Developers Terms Privacy Policy Safety How YouTube works Test new features Press Copyright Contact us Creators. I had problems with my steering mechanism similar to what you are experiencing. It began as an occasional stutter transmitted all the way to the steering wheel when turning to the right.
Ended by leaking fluid. I had it replaced in Detroit where it developed the leak on our 2010 loop trip. Just last week at the end of a day of boating as I was about to trailer the boat I felt a strong vibration or thudding sound at very low RPMs.
Have replaced all of the following on 2004 Volvo Penta DP steering. Cable Helm Actuator Power Steering Pump relief valve Also tested ps pump pressures and were in spec. Outdrive swings free cable moves easily to allow actuator movement.
Steering was still inconsistent and sloppy at all speeds Bit the bullet and spent 110000 on a Seastar hydraulic system that still keeps the factory power steering. If the steering was fine before the pump was sent out but now hard to steer in 1 direction now that the pump is back in the problem is more than likely the high pressure relief valve inside of the pump is sticking open and not allowing the pump to build up pressure. Volvo Penta 570A Power Steering Issue.
By tiveroz in forum Volvo Penta Gas Engine Forum Replies. 57 DPE Volvo Penta Power Steering Conversion. By arnoldwhipple in forum Volvo Penta Gas Archive Replies.
Volvo Penta 43 gl Power Steering. The Bentley GT is a four wheeled version of Volvo Penta in terms of gremlins mostly sensor or connection issues. How ever the dealer software for interrogation is 300 and freely available it does the rest of the VAG com group to Audi VW Porsche Seat Skoda and Lamborghini as well as Bentley they share the same pulse Modulation signal.
After the Power steering control valve 1 0 014VP21914259 VALVE 217333 and all of the power steering lines and purged the system the boat worked for 1 hour until the same issue arose again. Im depressed and have no where to go. Local techs have no idea.
I have a 2002 Volvo penta 50 gxi-a. The steering is hard to turn to the left when under power or in netural. With engine off it turns in both directions with no problem.
All fluid levels are ok. Power steering pump sounds normal. I have a seastar helm and seastar model 92vps cylinder attached to a Volvo penta steering actuator.
2003 volvo penta 81 gi I changed power steering pump blown seal now my boat cranks but will not start fuel pump cycles with key I did notice when I turn on key it cycles and. Volvo penta 30GS MEFS 2000 Engine will run all day at 2000 rpm but at 3000 RPM bogs down and dies. It wouldnt surprise me if its not the same clamp as mine.
Lay okb the engine follow the par str hose to the starboard rear corner of the engine. The hose goes to the power steering cooler. If its wet there cut the clamp off with a side cutter and put a screw clamp or 2 in its place.
I had incredibly tight steering that I traced down to a bad helmcable that I have on order. With the cable disconnected I tried moving the outdrive and it wouldnt move. I removed the steering ram to check it and with the flats on the actuator oriented horizontally the cylinder will move and push fluid but when hooked up and the engine running it wants to constantly turn the outdrive to the starboard side.
I have a volvo penta 57 just had power steering fixed now steering wheel is hard to the left but turns easy to the right pump has been bled of any air. Volvo Penta power steering leak - removing the leaking steering actuator. My Four Winns Horizon 230 inboard outboard developed a whine that I determined was.
Jun 15 2004. Hydraulic Steering Noise Volvo Penta 57Gi w DP. Out of curiosity has anyone ever hear a loud squeelchatter coming from what appears the belt driven pump for Hyd Steering fluid.
Condition exists only at moderate to high RPM 2000-3600. Not the outdrive jointsbearings they are new and the noise isnt back there. Volvo Penta with sterndrives and Joystick.
I replaced the steering sensors lift cylinders every hydraulic line the steering computer a power steering control valve power steering pump. Immediately after I start it up it goes into Limp mode with a steering warning error. Approved power steering fluids such as GM power steering fluid or Dexron II automatic transmission fluid can also be used.
Do not overfill the pump reservoir. Steering System Lubrication At the beginning of each boating season grease the steering ram with Volvo Penta grease. I have done 1000s of miles with Volvo Penta 10 000s likely.
I have a lot of respect for TAMD41s including the 290 AQAD outdrive version. The Volvo Penta DPH drives can be a problem my post was designed to help forum members from getting stranded and thus reducing the unreliability. Glastron Steering problems My boat is a 2005 Volvo Penta 185 V6.
It is as said by prc03sx195 there is a 30 degree slop either way of TOC. A bad steering arm might be something to check but after less than 60 hours on this boat is that normal. We only have about two months of really good boating in my neck of the woods.
PicClick Insights - Volvo Penta 21910902 SX Power Steering Actuator Ram Cylinder Assembly 3812269 PicClick Exclusive. Popularity - 11788 views 103 views per day 1149 days on eBay. Super high amount of views.
54 sold 69 available.